Let's see in this guide the main steps to be able to change the transmission oil of the second series Fiat Ducato, with 2.8 JTD engine. First of all we lift the car and go to locate the gear oil vent bolt, which we find near the transmission; we use a hex wrench to unscrew it, letting it drain the old oil in a container for about ten minutes. Turn the key ON and check that the initial check on the MIL and CODE warning lights takes place. Then check: 1.if the inertia switch has cut in; - reset inertia switch. 2.presence of fuel in the tank; - feed pump located in the fuel tank is operating - The tank pump will go off after 30 seconds.
Points. 68. Jul 3, 2013. #4. 2.1 litres of 75w synthetic gear oil. Drain out what's left, throw it away and fill from the breather at the top. It's been a year since I refilled mine, but I seem to remember that it was best to take out the aircleaner assembly to get to the filling point.
hi have had two faults which main fiat dealers and other so called auto electricians cant solve.First engine starts ok but engine light stays on followed by the heater coil light flashes on and off for about thirty seconds then goes off. fault codes are 0380 board relay thermo starter or pre heater. 1612 deisel filter heater rely. Points. 54. May 25, 2008. #4. This is for a 2003 Ducato 2.8: The gearchange works with two cables; one for fore/aft and the other left/right. There is a nylon block in the dashboard fitting under the gaiter to which the top ends of the cables are attached, and the other ends go to separate attachment brackets on the gearbox case.

223. Location. Sunshine Coast Qld, Aust. Jul 26, 2014. #2. That is the correct drain plug, the original quantity was 2.0litres but has been revised to 2.7 so as to allow better lubrication of the fifth gear that is outside the main case. It is good idea to use the original oil as jreplacement Tutela SAE 75W-85 APIGL4. Cheers.

Page 191 Version 15 Engine Engine Bodywork code version Combi short wheelbase automatic gearbox low roof 2.8 JTD 8140.43S 244APARA 30 Van high sided medium wheelbase 2.8 JTD 8140.43S 244APMNB AX Van high sided medium wheelbase 2.8 JTD 8140.43S 244APMNB BX Ambulance van short wheelbase low roof without EGR 2.8 JTD 8140.43S 244ALMFA AY
Order spare parts for your FIAT Ducato II Van (244) 2.8 JTD 4x4 (128 hp) Diesel cheap online. Find spare parts for any FIAT model on Car-parts.ie. More than 1,000,000 original-quality spare parts for cars, trucks, and SUVs at everyday low prices!
400. Points. 90. Location. Adriatic island. Aug 25, 2017. #5. The A/C belt can be cut with a sharp knife, the new belt must be the flexible type that can be stretched without damage. To install it, place it in position and keep it there with a piece of duct tape, then briefly turn the ignition key.
Fiat Ducato 18 JTD 2.8 needs a new engine. Disaster stuck while in France last week and the cam belt failed on my Lunar Roadstar, a Fiat Ducato 18 JTD 2.8, while leaving a Lidl car park. I was in first gear doing about 5 mph. To be honest the noise it made I initially thought the exhaust had hit the road. The MH is currently in France awaiting
My oil filter needed changing as well when my Ducato (2015) went into limp mode. Very embarrassing when i came to a hill. after the filter was changed , which i did myself, i had some problems with possible contamination in the line and low pressure on one injector. Location. Sunshine Coast Qld, Aust. Apr 26, 2011. #7. Hi. Neither of those Workshop Manual versions cover the 2.8TD or 2.8TDi ? In the eLearn version only the 2.8 JTD version is covered as well as the 2.2 & 2.3 JTD engines (in the DTE ver also the 2litre petrol & also JTD versions of the 1997 & 2300 engines) so they are all CRD engines. The JE CHANGE LE FILTRE A GAZOIL ET LE FILTRE A AIR SUR MON CAMPING CAR FIAT DUCATO 2.8 IDTD ANNEE 2002 #campingcar #filtres #mecanique #entretien 1. Location. Nottingham. Jun 21, 2012. #4. Hi, Had the same problem with the clutch slipping very slightly, taking a moment to come down revs when changing up and also increasing slippage noticable with slightest pressure on the pedal in 5th gear. Decided to have the clutch changed ( at 20K ! ) on my 2.8jtd motorhome as I had got stuck once or Hi yes it does, suggest you drain it first & save or replace the oil, the plug is under the final drive assembly (old internal square type). Original Specs say 2 liters but it should have 2.7 to save the 5th gear from oil starvation. If you replace the oil make sure it is the correct type as some oils can damage the sycro rings -see other posts Q4Ua5dF.